1. General Introduction
The module includes Intrinsic Safety protection components on each channel for connection to process equipment in hazardous areas without the need for additional external devices.
Each channel can drive a nominal current of 40 mA into a 300 ohm field load such as an Ex certified solenoid valve, alarm sounded unit or indicator lamp. Open and short circuit detection can be configured for each channel. All four channels are galvanic isolated between channels and from the Module Bus and power supply. Power to the output stages is converted from the 24 V on the power supply connections.
TU890 and TU891 Compact MTU can be used with this module and it enables two wire connections to the process devices without additional terminals. TU890 for Ex applications and TU891 for non Ex applications.
2. Specification of DO890
General info | |
Type | Digital Output |
Signal specification | 11 V, 40 mA |
Article number | 3BSC690074R1 |
Number of channels | 4 |
Signal type | Solenoid driver |
HART | No |
SOE | No |
Redundancy | No |
High Integrity | No |
Intrinsic safety | Yes |
Mechanics | S800 |
Detailed data | |
Isolation | Individually isolated, channel-to-channel and to circuit common ground |
Output load | 100 - 5000 Ω |
Current limiting | Short circuit proof current limited output |
Rated insulation voltage | 50 V |
Dielectric test voltage | 500 V a.c. |
Power dissipation | 4.4W |
Current consumption +5 V Module bus | Typ. 80 mA, Max. <150 mA |
Current consumption +24 V external | Typ. 250 mA, Max. <360 mA |
Diagnostics | |
Front LED’s | F(ault), R(un), W(arning), O(SP), Channel 1-4 status |
Supervision | Internal process supply Short circuit fault detection limit < 20 Ω Open circuit fault detection limit > 100 kΩ Fault sense current < 4 mA |
Status indication of supervision | 256, 512, 1024 ms |
Environmental and certification | |
CE mark | Yes |
Electrical safety | IEC 61131-2, cFMus |
Hazardous location | ATEX/IECEx Zone 2 with interface to Zone 0, cFMus C1, Div 2/Zone 2 with interface to C1, C2, C3 Div 1/Zone 0 |
Marine certification | ABS, BV, DNV-GL, LR, RS, CCS |
Protection rating | IP20 according to IEC 60529 |
Corrosive atmosphere ISA-S71.04 | G3 |
Climatic operating conditions | 0 to +55 °C (Storage -25 to +70 °C), RH=5 to 95 % no condensation, IEC/EN61131-2 |
Pollution degree | Degree 2, IEC 60664-1 |
Mechanical operating conditions | IEC/EN 61131-2 |
EMC | EN 61000-6-4 and EN 61000-6-2 |
Overvoltage categories | IEC/EN 60664-1, EN 50178 |
Equipment class | Class I according to IEC 61140; (earth protected) |
Max ambient temperature | 55 °C (131 °F), for vertical mounting 40 °C (104 °F) |
RoHS compliance | DIRECTIVE/2011/65/EU (EN 50581:2012) |
WEEE compliance | DIRECTIVE/2012/19/EU |
Comp ability | |
Use with MTU | TU890, TU891 |
Keying code | AB |
Intrinsic Safety parameters | |
U0 (Groups CENELEC USA) | U0 = 26 V (IIC AB) |
I0 (Groups CENELEC USA) | I0 = 93 mA (IIB CE) |
P0 (Groups CENELEC USA) | P0 = 605 mW (IIA DFG) |
U0 - C0 (uF) | 0,099 |
U0 -L0 (mH) | 77 |
U0 -L/R (uH/O) | 41 |
I0 - C0 (uF) | 0.77 |
I0 -L0 (mH) | 16,4 |
I0 -L/R (uH/O) | 234 |
P0 - C0 (uF) | 2.6 |
P0 -L0 (mH) | 32,8 |
P0 -L/R (uH/O) | 469 |
Dimensions | |
Width | 45 mm (1.77”) |
Depth | 102 mm (4.01”), 111 mm (4.37”) including connector |
Height | 119 mm (4.7”) |
Weight | 0.20 kg (0.44 lbs.) |
3. Selection table of I/O Modules
Name | HART | High Integrity | Intrinsic safety | Mechanics | Redundancy | SOE | Type |
DI801 | No | No | No | S800L | No | No | Digital Input |
DI802 | No | No | No | S800L | No | No | Digital Input |
DI803 | No | No | No | S800L | No | No | Digital Input |
DI810 | No | No | No | S800 | No | No | Digital Input |
DI811 | No | No | No | S800 | No | No | Digital Input |
DI814 | No | No | No | S800 | No | No | Digital Input |
DI818 | No | No | No | S800 | No | No | Digital Input |
DI820 | No | No | No | S800 | No | No | Digital Input |
DI821 | No | No | No | S800 | No | No | Digital Input |
DI825 | No | No | No | S800 | No | Yes | Digital Input |
DI828 | No | No | No | S800 | No | No | Digital Input |
DI830 | No | No | No | S800 | No | Yes | Digital Input |
DI831 | No | No | No | S800 | No | Yes | Digital Input |
DI840 | No | No | No | S800 | Yes | Yes | Digital Input |
DI880 | No | Yes | No | S800 | Yes | Yes | Digital Input |
DI890 | No | No | Yes | S800 | No | No | Digital Input |
DO801 | No | No | No | S800L | No | No | Digital Output |
DO802 | No | No | No | S800L | No | No | Digital Output |
DO810 | No | No | No | S800 | No | No | Digital Output |
DO814 | No | No | No | S800 | No | No | Digital Output |
DO815 | No | No | No | S800 | No | No | Digital Output |
DO818 | No | No | No | S800 | No | No | Digital Output |
DO820 | No | No | No | S800 | No | No | Digital Output |
DO821 | No | No | No | S800 | No | No | Digital Output |
DO828 | No | No | No | S800 | No | No | Digital Output |
DO840 | No | No | No | S800 | Yes | No | Digital Output |
DO880 | No | Yes | No | S800 | Yes | No | Digital Output |
DO890 | No | No | Yes | S800 | No | No | Digital Output |
Address: P.O. Box 17033, Jebel Ali Free Zone - South 2 Dubai, United Arab Emirates
Tel: +971558915937
Fax: +971558915956
E-mail:
info@rostockgroup.com
technical@rostockgroup.com
commercial@rostockgroup.com
Get the latest special offers and discount information sent to your email address.
Copyright © Rostock Group Co.,Limited All Rights Reserved. Sitemap